|
|
Sorry for not giving an update. We were not able to duplicate the surging on the ground with fuel set up gauges attached so went flying again and have not had a problem again over the past twenty some hours. As Mike Bush always says, when experiencing engine problems, perform tests in flight to help evaluate the engine data on the ground. Testing turned up nothing conclusive. There were no fluctuations in pressure or flow even though I could feel and hear the surging every time the low boost was turned on and it would absolutely run smooth again when the low boost was turned off.
Continental as well as my mechanic believe there was simply some blockage (trash) in the fuel pump. Despite what they said, I find it hard to believe or understand, however I have not had the problem return. Maybe they are correct as the pump cannot repair it's self, so what else could it
be?
Sorry I don't have something more to help you.
Art
Sent from Yahoo Mail for iPad |
From:
Colyn Case <colyncase@earthlink.net>;
To:
Lancair Mailing List <lml@lancaironline.net>;
Subject:
[LML] Re: Engine surging
Sent:
Fri, Dec 13, 2013 3:16:07 AM
Art,
on my IV-P the fuel flow actually decreases slightly with the electric fuel pump on.
did you watch fuel flow (and fuel pressure if you have it) while you were doing this?
Colyn
On Oct 2, 2013, at 7:48 AM, Bill Bradburry wrote:
Art,
Explain this phenomenon to the guys at GAMI. I bet they can explain what is
happening to your engine.
http://www.gami.com/contact/contact.php
B2
-----Original Message-----
From: Lancair Mailing List [mailto:lml@lancaironline.net] On Behalf Of Art
Jensen
Sent: Tuesday, October 01, 2013 2:57 PM
To: lml@lancaironline.net
Subject: [LML] Re: Engine surging
Charley,
The
surging was first noticed after take-off with low boost ON at about 800
feet AGL leaned for altitude 2500 RPM WOT. Being under the KFTG TCA climbs
were in steps to 9500 MSL where I leveled off to try to understand what's
going on and see how changes in operation affected what I was seeing and
feeling. I reduced power and went LOP same results. Then turned off the low
boost and the surging stopped. The engine ran very smooth. Turned the low
boost back on and the surging came back. Again I turned it off and it went
away. I determined I had found the cause (fuel pump) but still don't
understand why (what is beginning to fail) or the connection (how it plays a
roll to create the results I experienced).
Still looking for the expert who can put it all together so that I can come
up with a plan of action for repair.
Called Lancair to price a new Dukes Fuel Pump, $3350, might be a bargain
tomorrow but at that
price I'm not going to R&R as a test. Haven't checked a
price for overhaul assuming my problem is in fact the pump.
Any and all advice appreciated.
Art
Sent from my iPhone; Art Jensen
> On Oct 1, 2013, at 1:30 AM, Charles Brown <browncc1@verizon.net> wrote:
>
> Just a thought ... if there wasn't any rpm change, and you heard or felt
surging, it could be a torque increase that causes a pitch increase, and
increased thrust. And if MP was constant, then the only thing *that* leaves
is mixture. If you're running lean of peak, power depends significantly on
mixture.
>
> The thing is, this sounds backwards. If it's worse when you turn the
boost pump ON, then it sorta seems that you were running so far rich of peak
that additional fuel pressure degraded power? I'm not aware that
the engine
can even produce a mixture that overrich, except at very low power settings.
> Charley
>
> On Sep 30, 2013, at 7:58 AM, Art Jensen wrote:
>
> Looking for thoughts from the collective minds of the LML. Last flight in
my IO-550 normally aspirated legacy, I noticed surging in the engine with
the low boost pump on. I did not notice any surging when I turned the boost
pump off. Also did not notice any fluctuation in RPM. Nor did I see any
fluctuation in RPM when I downloaded the engine data. The obvious question
would be what are the possible causes and does it make the airplane unsafe
for flight as there is no surge when the boost pump is off. I don't
understand how I could feel and hear surging in the engine yet see no
fluctuation in RPM, so I'm stumped. Any ideas would be appreciated, thank
you.
> Art
>
> Sent from my iPhone; Art Jensen
> --
>
For archives and unsub
http://mail.lancaironline.net:81/lists/lml/List.html
>
>
> --
> For archives and unsub
http://mail.lancaironline.net:81/lists/lml/List.html
--
For archives and unsub http://mail.lancaironline.net:81/lists/lml/List.html
--
For archives and unsub http://mail.lancaironline.net:81/lists/lml/List.html
--
For archives and unsub http://mail.lancaironline.net:81/lists/lml/List.html |
|
|